Traditional transmission fluids are not suitable for use in this application. Ford 2002 excursion owner' manual pdf download. While Ford doesn't state synthetics or what specific element exists in Mercon V that causes issues, plain Mercon a non-synthetic is the requirement. Fill the reservoir as needed and visually inspect the power steering system for leaks. Sounds like he was trying to sell you whatever he had. Check the fluid level and fill to the full warm level.
You can do a search on the internet for this information if you want, and find tons of info on this. The is a case where the cheapest is better, no additives or inhibitors added, the trans does not like those things. Release the vacuum and remove the vacuum source. I think I know what you are trying to convey. Turn the ignition switch to off. This Technical Service Bulletin is designed to provide back ground into different transmission fluids past and present. Maintain maximum vacuum with the source.
Fill until the fluid starts to dribble out of the filler hole. Ford Part Number Xt 2 Qdx - 2003 ford -350 super duty 6. Already put a new pump on. We are going to help you to get articles Ford Part Number Xt 2 Qdx you're looking at some of our content which might be suitable as you are looking for the material. Tightly insert the stopper of the vacuum pump into the fluid reservoir.
Ensure the correct automatic transmission fluid is used. This guy was steering me in the wrong direction. Did you read the Ford Special Service Message above? I think I know what you are trying to convey. Already put a new pump on. Refer to the procedure in this section. Our Ford parts and accessories are expedited directly from authorized Ford dealers strategically located all across the U.
This has to be done properly as by the Ford shop manual. Start the vehicle and turn the steering wheel from stop to stop twenty times. If there is misinformation here, just wondering where? Use your little finger to reach inside the housing and feel the lubricant level. Refer to Transmission Fluid Capacity for specifications. As long as the fluid meets or exceeds that spec it will work fine. Verify this at the place where you buy the lubricant , either an auto parts store or Ford dealer with a service department!!! Why does Ford constantly make detrimental changes in their products? Install and tighten the plug securely and check for leaks after the first few miles of driving.
Be cautious when removing the drain plug: the transmission fluid can be very hot. Apply maximum vacuum 68-85 kPa 20-25 in-Hg for a minimum of three minutes at idle. Apply maximum vacuum 68-85 kPa 20-25 in-Hg for a minimum of three minutes at idle. Maintain maximum vacuum with the source. Add fluid to the appropriate level.
It can be replaced with Mercon or Mercon V specification. Allison Division no longer supports this specification. Troubleshooting tech tips - steering comp, Top of page. Allow the transmission fluid to drain into the pan. Install the fluid reservoir cap.
This type of drive train fluid should not be used in automatics that require Type F. There should be a similar plug higher on the transmission case, remove this and fill from there. Install the fill plug to 17 ft. Refer to the Martin Lubricants product label or Product Data Sheet for approved applications. Start the vehicle and immediately turn the ignition off to fill the components in the power steering system.
Jul 03, 2014 well there are a few different transmissions they put in this truck. Raise the front wheels off the floor. In the owners guide of the 2005 escape it does not say anything about non-synthetic mercon. But i would not waste money on a expensive synthetic in these trans as its overkill. Remove the fluid reservoir cap and check the fluid.
For all transmissions except for the Borg-Warner T5R, replace the transmission fluid at the first 15,000 miles 24,000 km and then every 30,000 miles 48,000 km thereafter. The Borg-Warner T5R transmission does not require periodic changing of the transmission fluid. See the seller's listing for full details. Remove the vacuum source from the fluid reservoir. Transfer case fluid - xl-12 - ford truck enthusiasts forums, 1999 to 2016 super duty - transfer case fluid - xl-12 - i'm getting ready to change out the transfer case fluid. Any mixture or any unapproved oil could lead to seal deterioration and leaks. Brand New: A brand-new, unused, unopened, undamaged item in its original packaging where packaging is applicable.