It's leaking right in front of the rear driver side wheel. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. Sometimes, however, your Chevrolet Cobalt fuel lines and hoses can fall victim to the rigors of rust and old age. With both coupe and sedan versions available starting at a low entry price, the Cobalt offers something for everyone. It may be a gasket.
The vehicle was towed to the dealer where the technician diagnosed that the valve kit had melted and the fuel pump needed to be replaced. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Does the hole in the tank appear to of occurred due to a tank fastener or other devices around the tank itself? The potent engine is mated to a 5-speed manual. This location was right next to the exhaust pipe so danger level was extreme, especially considering the sheath was soaked with a lot of gas. The key fob if applicable , should also be removed from the key ring. Doing it yourself is good, just be careful and make sure the car is cold, disconnect the battery to prevent electrical sparks, and use ventilation to remove fuel vapors.
The manufacturer was made aware of the failure. Make sure it is protected from exhaust lines, bends and sharp metal areas. Nylon repair kit will replace your rusted out steel lines from the filter to mid way up the car and vent line from canister to midway. It is always a gamble. The recall began on July 17, 2014. As its life only covers five years, it had been have minor changes. Simply pick the connector or fitting you want for Hose End 1 and then pick the connector or fitting for Hose End 2.
Standard safety equipment across the range includes dual-stage front airbags as well as head curtain side-impact airbags, daytime running lights and one year of OnStar Safe and Sound service. It also had a longer wheelbase than its competitors, giving it increased balance and stability. Why must someone be killed, hurt or maimed if this hasn't already happened before action is taken? It'll help if you'll test-drive several Cobalts from various sellers to see the difference in performance and in overall condition. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. The 15W-40 semi-synthetic motor oil, on the other hand, is highly recommended for driving in summer or in higher temperatures. John answered about a year ago That may indicate air in the fuel system so the leak may be a connection at the pump connectors, or the line at the connection.
If the blood of your Chevrolet Cobalt engine is the gas or diesel that powers it, then the fuel lines and hoses would be its veins. Ideally I can fix it on my own for very little. The contact stated that the vehicle failed to start. Our website offers high-quality Chevrolet Cobalt genuine parts at the lowest price with manufacturer's warranty. Check and see if there is a copper line that can be used and good fasteners. All they want is for the mech. I left my fiance in the running car while I ran into a store and a few minutes later he came and got me saying we have to leave right now! Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008.
Be safe, spend the few bucks, it far less than the deductible on your home owner's insurance policy. This tells me there are a lot of auto mobiles out there with this problem. Make all your future car parts purchases at carpartsdiscount. Need too get it up and an correct the problem or call our local dealer on any recall. Gas leaks not only decrease gas milage, but can cause fires. It also has a good set of safety features. Sometimes a white tape wrap around the fitting will reseal the connection.
Dealing with gas and the exhaust system and cat under the car, I'd not dilly dally around. The key fob if applicable , should also be removed from the key ring. Aside from these faulty systems and parts, some owners have reported ignition troubles like a stuck key caused by a faulty shifter and a broken ignition module and defective coil, which could result in a misfire. More significant and noticable, however was the restyling of the console, the steering wheel, as well as the radio unit—finally integrating an audio input jack for portable music players. The Cobalt adds standard amenities that make the vehicle a smoother, more comfortable and even more practical choice.
Seat belt, protector of occupants from sudden movement such as emergency braking should get same attention as well. Do not let the gas leak go on, as it is very flammable, and you may wind up with a really hot car. Though it is inevitable that as the increase of usage, some auto parts will wear out, however, the most frequent problems on it are as follows: First, suspension system problem. I decided not to waste time driving a potential fire bomb as gas was dripping quickly. If you have also found above symptoms, you are suggested to check your steering column or shift cable immediately. The mechanic stated that the connection to the fuel pump was melted. On the opposite end of the original nylon line, there are connectors.
Great cars and trucks like your Cobalt need great parts. O External Fuel Filter Location: Engine to Hose Connection off Fuel Tank Nylon Line Attached to Vapor Line The nylon line attached to the new vapor line is not a direct replacement. What would be the best type of motor oil to use on the Chevy Cobalt? This expansion represents an additional 823,788 vehicles. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. The lines on top of the tank tends to leak in time for some reason,,, since they are pretty much pressed against the frame,,. Would this be covered under a recall then? Inevitably your fuel will begin to leak, and they will need to be replaced as soon as possible. Don't always go to the first garage unless you really trust them.
I put the car up on a lift and found that it's leaking somewhere where the line is wrapped in heat tape when it crosses over the exhaust. The rest of the line was in good shape. Or is the cable cracked. The 2010 Chevrolet Cobalt blends attractive styling with a host of engine choices, from fuel-sipping to fast and furious. Given all the trouble that can be involved with fixing broken parts on your car or truck, let www. When driving in colder places, the 5W-40 fully synthetic oil may be a better option as this is known to perform well in lower temperatures.